Difference between revisions of "Mercedes maintenance"

From Finninday
Jump to: navigation, search
Line 12: Line 12:
  
  
===Maintenance===
+
 
  
  
Line 35: Line 35:
 
Should cost between $10 and $30 depending on brightness, life span, color temperature.
 
Should cost between $10 and $30 depending on brightness, life span, color temperature.
 
The cheaper ones should last longer because they aren't burning as hot.
 
The cheaper ones should last longer because they aren't burning as hot.
 +
 +
===Maintenance log===
  
 
====January, 2016====
 
====January, 2016====
Line 105: Line 107:
 
for $83
 
for $83
 
It recommends using a rivet gun to make the job easier.
 
It recommends using a rivet gun to make the job easier.
 +
 +
Replaced the window lift motor and only broke a few of the door panel clips.

Revision as of 19:53, 24 April 2019

1995 Mercedes E320 Wagon

  • Original equipment tire size: 195/65-15
  • W124 chassis




rear brake light bulbs

12-volt 21-watt 1156

The configuration of the lights in the rear tail light cluster is four bulbs arranged vertically. From top to bottom:

  • brake light 12-volt 21-watt 1156 P21W
  • reverse light 12-volt 21-watt 1156 P21W
  • turn signal 12-volt 21-watt with offset pin 7507 P21W
  • running light ??? R10W

headlight bulbs

  • Sylvania type 9003

The high and low beams are contained in the same bulb. Should cost between $10 and $30 depending on brightness, life span, color temperature. The cheaper ones should last longer because they aren't burning as hot.

Maintenance log

January, 2016

Heater blower regulator replaced, cowl drain cleared

July, 2015

New cabin air filters, new engine air filter

Cabin air filter https://www.youtube.com/watch?v=2m5oPNdFkW4

Engine air filter https://www.youtube.com/watch?v=SlgdrhV_B-M

March 2015

Checkup, new tires, new front coil springs, new front wheel bearings, wheel alignment

Feb 2016

Car stalled while driving. Would crank, but not start. Towed to the mechanic and it started, but is running rough.

Caused by misfires on cylinders 1 and 3. No spark from coils 6 and 4. Ignition coils for cylinders 4 and 6 have failed. Spark plugs and ignition wires worn.

Installed 3 ignition coils. Installed ignition wires. Installed 6 spark plugs. $900

Oct 2017

Engine warning light comes on while we are travelling to Colorado.

Passenger side low beam burns out. Replaced a bulb. No tools required.

https://www.youtube.com/watch?v=2i3TEdL3rlc

The year is wrong and the headlight configuration looks different, but the procedure works.

Feb 2018

Front windshield wiper and rear defrost intermittently fails. When you wiggle the fusebox, it will sometimes begin to work. Replaced the aluminium fuses with copper and fixed the problem.

Here is the fusebox Fusebox.jpg Fuse-diagram.jpg

Someday, we'll probably have to replace the wiring harness. https://www.youtube.com/watch?v=kz6K1v2R13Q


July 2018 broken oil fill cap

I used some channel locks on the oil cap to loosen it and broke the plastic form. After the break, the dashboard warning light for oil level started coming on regularly, even when the oil level is fine. Ordered a new one from Rock Auto.

Dec 2018

Car is beginning to struggle to start. It feels like the battery is about to fail. Some batteries for sale on the web claim that this battery requires professional installation because it is vented. But the E320 wagon doesn't have the battery in the trunk and therefore is not vented. I think. Rock Auto shows prices ranging from $164 to $183 https://www.rockauto.com/en/catalog/mercedes-benz,1995,e320,3.2l+l6,1195578,electrical,battery,2476 But I still have to drop off the old battery for recycling, so I might as well buy my battery from somewhere local that will do the recycle for me.

Got a new battery at Meineke.

April 2019

Left rear window no longer goes fully up and down. It partially works, but makes a scraping sound and stops before completely closing.

Buy replacement part from Rock Auto https://www.rockauto.com/en/moreinfo.php?pk=6335847&cc=1195578&jsn=422 for $83 It recommends using a rivet gun to make the job easier.

Replaced the window lift motor and only broke a few of the door panel clips.